TM 5-6350-280-23&P
2.6 INSTALLATION INSTRUCTIONS.
The following installation instructions are recommended:
NOTE
·
The power cable between the UPS and the CMA must be able to supply a
minimum of 6 amps.
·
The power cable between the UPS and the personal computer must be able to
supply between 6 and 15 amps.
a.
Install power cables from UPS to location of CMA and computer.
b.
Install UPS Cable Assembly from UPS to CMA.
c.
Route one end of UPS Cable Assembly through opening in bottom of CMA.
d.
Connect UPS cable to AC INPUT FAIL ALARM of the UPS and J1 of the Input/Output (I/O) (CCA) in the CMA.
e.
Route connector of RS-485 Cable Assembly with ground wire through opening in bottom of CMA.
f.
Connect ground wire of RS-485 cable to mounting screw of I/O CCA and connect connector to J2.
g.
Route the other end of the RS-485 Cable Assembly to Communications CCA installed in computer and connect to
the top connector of the Communications CCA.
h.
At personal computer, install a multiple outlet strip with at least three receptacles on power cable from UPS. Plug
in user furnished IBM-PC/AT compatible computer, color monitor, and dot matrix printer.
i.
At CMA, install a receptacle on power cable from UPS location and plug in CMA multiple outlet strip.
j.
Install a three prong plug on power cables from CMA location and computer location.
k.
Select a dedicated circuit on power distribution panel. Route a power cable to the UPS location. Connect the
UPS and ensure it is wired for the correct input voltage.
l.
Set dedicated circuit at power distribution panel to on position.
m.
Set UPS AC LINE INPUT BREAKER to on and observe that AC LINE INPUT indicator is lit.
n.
Set BATTERY BREAKER to on then INVERTER OUTPUT BREAKER to on.
o.
Depress Inverter ON/OFF switch. Wait 2 seconds then observe INV OUTPUT indicator is illuminated.
p.
Using VOM, check voltage at output of UPS.
q.
Plug CMA and computer into UPS.
r.
Power on computer, and ensure MS-DOS version 3.2 or higher is installed.
s.
Install AMG software as follows:
(1)
Remove disk labeled "AMG PC Software Diskette 1" from protective sleeve and insert into 5 1/4 inch floppy
drive.
2-3
